Preparation of Porous Porcelain with Treated Flue Gas Desulfurization (FGD) Sludges the Foaming Agent-Reference-Cited by-同舟云学术

Preparation of Porous Porcelain with Treated Flue Gas Desulfurization (FGD) Sludges the Foaming Agent

Published:2022-01-28 Issue: Volume:908 Page:245-249
ISSN:1662-9795
Container-title:Key Engineering Materials
language:
Short-container-title:KEM

Author:

Alias Suffi Irni¹,Johar Banjuraizah¹,Adam Syed Nuzul Fadzli¹,Taib Mustaffa Ali Azhar²,Othman Fatin Fatini¹,Yahya Hamdan³

Affiliation:

1. Universiti Malaysia Perlis (UniMAP)

2. ADTEC Division of Advanced Ceramic Materials Technology

3. Department of Mineral and Geoscience Malaysia (JMG)

Abstract

The potential of treated FGD sludge as foaming agent in ceramic porcelain were studied. The effect of treated FGD sludge content on phase composition, porosity and mechanical strength of porous ceramic were investigated. The result showed that the addition of treated FGD sludge improve the porosity. However, the increased porosity significantly reduced the flexural strength in sample after sintering at 1200°C for 3 hours. The porous of ceramic porcelain produced in this study can be used for insulation in high temperature application.

Publisher

Trans Tech Publications, Ltd.

Subject

Mechanical Engineering,Mechanics of Materials,General Materials Science

Link

https://www.scientific.net/KEM.908.245.pdf

Reference12 articles.

1. S. Sarkar, S. Bandyopadhyay, A. Larbot, and S. Cerneaux, New clay–alumina porous capillary supports for filtration application, J. Memb. Sci. 392 (2012)130–136.

2. R. A. Shkrabina, B. Boneckamp, P. Pex, H. Veringa, and Z. R. Ismagilov, Porous structure of alumina ceramic support for gas separation membranes, II. Study of porous structure of ceramic composition, React. Kinet. Catal. Lett. 54 (1995) 193–201.

3. D.A. Ivanov, S.D. Shlyapin, G.E. Val'yano, and L.V. Fedorova, Structure and physicomechanical properties of porous ceramic based on Al2O3 prepared using a filtration combustion method, Refract. Ind. Ceram. 58 (2018) 538–541.

4. Z. Sun, C. Lu, J. Fan, and F. Yuan, Porous silica ceramics with closed-cell structure prepared by inactive hollow spheres for heat insulation, J. Alloys Compd. 662 (2016) 157–164.

5. Q. B. Chang, X. Q. Liu, X. Wang, Y. Q. Wang, and J. E. Zhou, Preparation of porous ZrO2-Al2O3 composite ceramic with high strength and good corrosion-resistance, Adv. Mat. Res. 197 (2011) 1545–1548.