Affiliation:
1. Department of Mechanical Engineering, University of Ibadan, Ibadan, NIGERIA
Abstract
Orange peels are considered a waste, and the increase in cultivation and processing of oranges tends to increase waste in society. This work is designed to convert waste to wealth by investigating the potential of biodiesel production from orange peels and its suitability as an alternative fuel in compression ignition (CI) engines. Steam distillation pilot plant was used to extract oil from the orange peels, 1.27% was its maximum oil yield recovery. The oil was transesterified using methanol at a 6:1 molar ratio with 0.70% sodium hydroxide as the catalyst at 55 <sup>o</sup>C for 60 minutes and 96.00% biodiesel yield recovery was obtained. The biodiesel properties were found with density of 872 kg/m<sup>3</sup>, viscosity of 1.9 cSt, pH value of 7.6, calorific value of 38.4 MJ/kg, and flash point of 84 <sup>o</sup>C. The biodiesel was blended with diesel at different volumes, compared with pure diesel, and run on a CI engine. B20 (20.00% biodiesel, 80.00% diesel) has the optimum brake-specific fuel consumption rate and brake thermal efficiency and are respectively 9.08% lower and 11.99% higher than petroleum diesel. B15 (15.00% biodiesel, 85.00% diesel) has the optimum exhaust temperature and is 10.37% lower than diesel. B10 (10.00% biodiesel, 90.00% diesel) has the optimum carbon monoxide and carbon dioxide emissions and are 58.07% and 43.70% lower respectively than petroleum diesel.
Subject
General Earth and Planetary Sciences,General Environmental Science
Reference26 articles.
1. Aguiar, L., Marquez-Montesinos, F., Gonzalo, A., Sanchez, J.L., & Arauza, J. (2008). Influence of temperature and particle size on fixed bed pyrolysis of orange peel residues. Journal of Analytical and Applied Pyrolysis, 83(1), 124-130. https://doi.org/10.1016/j.jaap.2008.06.009
2. Bull, O. S., & Obunwo, C. C. (2014). Bio-diesel production from oil of orange (citrus sinensis) peels as feedstock. Journal for Applied Science Environmental Management, 18(3) 371-374.
3. Cataluna, R., & da Silva, R. (2012). Effect of cetane number on specific fuel consumption and particulate matter and unburned hydrocarbon emissions from diesel engines. Journal of Combustion, 738940. https://doi.org/10.1155/2012/738940
4. de Morais, L. C., Santos, C. M., & Rosa, A. H. (2015). Thermodynamic parameters of a solid biofuel from orange peel. Chemical Engineering Transactions, 43, 583-588. https://doi.org/10.3303/cet1543098
5. Deep, A., Singh, A., Vibhanshu, V., Khandelwal, A., & Kumar N. (2013). Experimental investigation of orange peel methyl ester on single cylinder diesel engine. SAE Technical Paper. https://doi.org/10.4271/2013-24-0171
Cited by
1 articles.
订阅此论文施引文献
订阅此论文施引文献，注册后可以免费订阅5篇论文的施引文献，订阅后可以查看论文全部施引文献