Measurements of the acid-binding capacity of ingredients used in pig diets

Abstract

Abstract Some feed ingredients bind more acid in the stomach than others and for this reason may be best omitted from pig starter foods if gastric acidity is to be promoted. The objective of this study was to measure the acid-binding capacity (ABC) of ingredients commonly used in pig starter foods. Ingredients were categorised as follows: (i) milk products (n = 6), (ii) cereals (n = 10), (iii) root and pulp products (n = 5), (iv) vegetable proteins (n = 11), (v) meat and fish meal (n = 2), (vi) medication (n = 3), (vii) amino acids (n = 4), (viii) minerals (n = 16), (ix) acid salts (n = 4), (x) acids (n = 10). A 0.5 g sample of food was suspended in 50 ml distilled de-ionised water with continuous stirring. This suspension was titrated with 0.1 mol/L HCl or 0.1 mol/L NaOH so that approximately 10 additions of titrant was required to reach pH 3.0. The pH readings after each addition were recorded following equilibration for three minutes. ABC was calculated as the amount of acid in milliequivalents (meq) required to lower the pH of 1 kg food to (a) pH 4.0 (ABC-4) and (b) pH 3.0 (ABC-3). Categories of food had significantly different (P < 0.01) ABC values. Mean ABC-4 and ABC-3 values of the ten categories were: (i) 623 (s.d. 367.0) and 936 (s.d. 460.2), (ii) 142 (s.d. 79.2) and 324 (s.d. 146.4), (iii) 368 (s.d. 65.3) and 804 (s.d. 126.7), (iv) 381 (s.d. 186.1) and 746 (s.d. 227.0), (v) 749 (s.d. 211.6) and 1508 (s.d. 360.8), (vi) 120 (s.d. 95.6) and 261 (s.d. 163.2), (vii) 177 (s.d. 60.7) and 1078 (s.d. 359.0), (viii) 5064 (s.d. 5525.1) and 7051 (s.d. 5911.6), (ix) 5057 (s.d. 1336.6) and 8945 (s.d. 2654.1) and (x) -5883 (s.d. 4220.5) and -2591 (s.d. 2245.4) meq HCl per kg, respectively. Within category, ABC-3 and ABC- 4 values were highly correlated: R2 values of 0.80 and greater for food categories i, iv, v, vi, vii and viii. The correlation between predicted and observed ABC values of 34 mixed diets was 0.83 for ABC-4 and 0.71 for ABC-3. It was concluded that complete diets with low ABC values may be formulated through careful selection of ingredients. The final pH to which ABC is measured should matter little as ABC-3 and ABC-4 are highly correlated.