Ammonia generation in Ns pulse and Ns pulse/RF discharges over a catalytic surface

Abstract

Abstract Plasma-catalytic ammonia synthesis in a ns pulse discharge and a ‘hybrid’ ns pulse/RF discharge in plane-to-plane geometry is studied by Fourier Transform infrared absorption spectroscopy. The data are taken in a preheated H2–N2 mixture, with and without Ni/γ-Al2O3 or Co/γ-Al2O3 catalyst placed in the discharge section. The measurement results are taken using two different approaches. The first is a ‘single-stage’ process, where a ns pulse discharge in the H2–N2 mixture is sustained continuously. In this case, the ammonia yield increases slowly, over a period of tens of minutes. The second is a ‘two-stage’ process, where the catalyst is first activated by the ns pulse discharge sustained in pure nitrogen, and then the activated catalyst is exposed to the H2–N2 flow, with or without the discharge. In this case, a strong overshoot of the NH3 number density at the reactor exit is detected, by over a factor of two compared to the single-stage process. After the initial overshoot, the ammonia yield gradually decreases to the ‘single stage’ value (with the discharge on), or to near zero (with the discharge off). The results demonstrate that the ammonia yield in the plasma-catalytic reactor is controlled by the N atom accumulation on the catalyst surface, which reacts with H atoms thermally dissociated on the catalyst or generated in the plasma. The results also show that the plasma-catalytic ammonia yield is significantly higher compared to that in the ns pulse discharge without the catalyst. The accumulation of H atoms on the catalyst, with their subsequent reactions with N atoms generated in the plasma, is of relatively minor importance at the present conditions. An additional series of measurements was made with a sub-breakdown RF waveform overlapped with the ns pulse discharge train, to enhance the vibrational excitation of nitrogen. The ammonia yield measured with the RF waveform added is approximately 20% higher compared to that at the baseline ns pulse discharge conditions, both with and without the catalyst. This effect is weaker compared to that of the catalyst activation by N atoms. Additional data are necessary to isolate the possible effect of the vibrationally excited N2 molecules on the ammonia synthesis in the plasma catalytic reactions.