Affiliation:
1. All-Russian Scientific Research Institute of Refrigeration Industry - branch of V.M. Gorbatov Federal Research Center for Food Systems of Russian Academy of Science
Abstract
Introduction. The research objective was to establish the effect of the complete and partial replacement of sucrose by trehalose on the dispersion of ice crystals in ice cream with a low mass fraction of fat and solids.
Study objects and methods. The present research featured three test samples of ice cream with a 3% mass fraction of fat: one with a complete replacement of sucrose (15.5%) and two with a partial replacement of 7.5% and 3%. In the control sample, the mass fraction of sucrose was 15.5%. To control the dynamic viscosity indicator of consistency, the research employed such an advanced method as rotational viscometry. Microstructure methods were used to determine the dispersion of ice crystals and the air phase.
Results and discussion. The usage of trehalose in the production of low-fat ice cream in the amounts of 3.0%, 7.5%, and 15% increased the dispersion of ice crystals and preserved it during storage. After three months of storage, most ice crystals in the test ice cream samples had a size of ≤ 45 μm with an organoleptic sensibility of ≤ 50 μm, while in the control sample (15.5% of sucrose) it did not exceed 60 μm. The experiment determined the effect of trehalose on the consistency of ice cream according to the following indicators: dynamic viscosity, overrun, and dispersion of the air phase. 15.5% of trehalose increased the dynamic viscosity of ice cream mix by 1.2 times as compared to the sample with the same concentration of sucrose. According to the average diameter of air bubbles, trehalose helped to preserve the dispersion of the air phase during storage. After three months, Sample 1 with 15.5% of trehalose demonstrated the maximum dispersion, which was 17% higher than in the control sample with a sucrose mass fraction of 15.5%.
Conclusion. The complete (15.5%) and partial (3% and 7.5%) sucrose replacement by trehalose in low-fat ice cream increased the dispersion of ice crystals and improved its consistency. Unlike the sample with 15.5% of sucrose, samples with trehalose had smaller ice crystals, which remained the same after three months. The trehalose samples had a better dynamic viscosity and air saturation. The research requires a further study of dispersion of ice crystals after 12 months of storage.
Publisher
Kemerovo State University
Subject
Industrial and Manufacturing Engineering,Economics, Econometrics and Finance (miscellaneous),Food Science
Reference19 articles.
1. Обеспеченность населения России микронутриентами и возможности ее коррекции. Состояние проблемы / В. М. Коденцева, О. А. Вржесинская, Д. В. Рисник [и др.] // Вопросы питания. – 2017. – Т. 86, № 4. – С. 113–124., Kodentsova VM, Vrzhesinskaya OA, Risnik DV, Nikityuk DB, Tutelyan VA. Micronutrient status of population of the russian federation and possibility of its correction. State of the problem. Problems of Nutrition. 2017;86(4):113–124. (In Russ.).
2. Сандракова, И. В. Исследование потребителей продуктов здорового питания / И. В. Сандракова, И. Ю. Резниченко // Практический маркетинг. – 2019. – Т. 274, № 12. – С. 22–27., Sandrakova IV, Reznichenko IYu. Health food consumers research. Practical Marketing. 2019;274(12):22–27.
3. O’Sullivan, M. G. Reduced-fat products and challenges / M. G. O’Sullivan // Salt, fat and sugar reduction / M. G. O’Sullivan. – Woodhead Publishing, 2020. – P. 63–96. DOI: https://doi.org/10.1016/B978-0-12-819741-7.00003-1., O’Sullivan MG. Reduced-fat products and challenges. In: O’Sullivan MG, editor. Salt, fat and sugar reduction. Woodhead Publishing; 2020. pp. 63–96. DOI: https://doi.org/10.1016/B978-0-12-819741-7.00003-1.
4. Совершенствование композиционного состава и структуры молочного мороженого / А. А. Творогова, Т. В. Коновалова, А. В. Ландиховская [и др.] // Техника и технология пищевых производств. – 2018. – Т. 48, № 2. – С. 109–116. DOI: https://doi.org/10.21603/2074-9414-2018-2-109-116., Tvorogova AA, Shobanova TV, Landikhovskaya AV, Zakirova RR. Milk ice cream composition and structure improvement. Food Processing: Techniques and Technology. 2018;48(2):109–116. (In Russ.). DOI: https://doi.org/10.21603/2074-9414-2018-2-109-116.
5. Ice cream: uses and method of manufacture / S. S. Deosarkar, C. D. Khedkar, S. D. Kalyankar [et al.] // Encyclopedia of food and health / B. Caballero, P. M. Finglas, F. Toldra. – Academic Press, 2016. – P. 391–397. DOI: https://doi.org/10.1016/B978-0-12-384947-2.00384-6., Deosarkar SS, Khedkar CD, Kalyankar SD, Sarode AR. Ice cream: uses and method of manufacture. In: Caballero B, Finglas PM, Toldra F, editors. Encyclopedia of food and health. Academic Press; 2016. pp. 391–397. DOI: https://doi.org/10.1016/B978-0-12-384947-2.00384-6.
Cited by
3 articles.
订阅此论文施引文献
订阅此论文施引文献，注册后可以免费订阅5篇论文的施引文献，订阅后可以查看论文全部施引文献